OCTOBER IS COOPERATIVE MONTHValid Oct 1 - 31, 2019
Discover the unique attributes of the cooperative business model
Grain is quickly coming out of the fields this fall, with 92 percent of soybeans and 73 percent of corn harvested in Iowa as of Oct. 26, according to the United States Department of Agriculture.
Since much of it has been harvested and put into the bin at 60 degrees and warmer, proper grain drying and cooling is essential for storage life and grain quality. For safe grain storage during warmer conditions, Greg Brenneman, agricultural and biosystems engineering specialist with Iowa State University Extension and Outreach says you need to
“With grain this warm, moisture migration within the grain mass and spoilage can occur very quickly, even with fairly dry grain,” said Brenneman.
Fines and broken grain tend to accumulate near the center of the bin and often cause aeration and storage problems. Brenneman recommends removing a few loads of grain from the center, so the unloading sump will “core” the bin and remove most of those fines. Then, remove grain until approximately half of that center peak is gone.
This week’s forecast shows cooler temperatures for Iowa, providing an ideal time to get stored grain cooled down. However, farmers may still need to run fans later this fall to lower temperatures further.
“The sooner you can lower grain temperatures, the better,” said Brenneman. “Grain should be stored at 30 to 40 degrees for winter storage, so you may still need to run fans a couple times during the fall to get grain down to wintertime storage temperatures.”
The time required to completely cool a bin of grain depends on fan size. In general terms, a large drying fan will take 10-20 hours to cool a bin of grain. However, a small aeration fan can take a week or more to completely cool a full bin.
In either case, it is best to measure the temperature of the air coming out of the grain to see if cooling is complete. It is also much better to err on the side of running the fan too long rather than turning it off too soon.
If grain is dried down to the proper moisture and correctly cooled, it should store very well through the winter. Even so, it is best to check stored grain at least every two weeks during the winter and once a week in warmer weather.
To do a good job checking grain, inspect and probe the grain for crusting, damp grain and warm spots. Also, run the fan for just a few minutes and smell the exhaust air for any off odors.
For more details, order a copy of “Managing Dry Grain in Storage” AED-20 from Midwest Plan Service at https://www-mwps.sws.iastate.edu/catalog/grain-handling-storage, or check out more grain drying and storage information at https://www.ag.ndsu.edu/graindrying.
Source: Greg Benne Iowa State University
Update your browser to view this website correctly. Update my browser now